• Mustang Forums
  • 1996 - 2004 SN95 Mustang -General/Talk-

2000 Ford Mustang GT 4.6 - Rear Differential

  • Thread starter Thread starter Misti
  • Start date Start date May 4, 2020

Misti

Member
Jun 23, 2019
31
9
18
Doniphan Mo
May 4, 2020
#1
  • May 4, 2020
  • #1
I Have Noticed Dark fluid leaking! It's in the back and I finally Investigated and Found this! I added a photo! So I bought a New Gasket and some Gear Oil to go with it! So I think I'm going to be changing this Gasket and figuring out how and why its bent like that. How do I get it out and do I just take a hammer to it?
 

Attachments

  • 15886403815962347140930889784383.webp
    113.9 KB · Views: 489
Reactions: stormsedge

stormsedge

5 Year Member
Jun 17, 2018
450
208
63
Here
May 5, 2020
#2
  • May 5, 2020
  • #2
It looks like a jack was put in the wrong place and bent the cover lip up...alternatively, the car was driven over something high enough to bend the cover back, but it really looks like it was "lifted" from below. In any event, you might first try tightening the cover bolts a bit---don't overtorque them---to see if it stops the leak (if it does, top your diff oil off). If not, covers can be had fairly cheap from salvage, or from aftermarket suppliers. With that in mind, if tightening it doesn't stop the leak, there is no reason not to work it a little with a hammer to try and get a straight edge for a seal(use a straight edge to judge your work...ALSo, check to see if the cover is cracked. The hardest part of this job for me was figuring out a good way to get the oil back in it...a lot of obstructions on the front side, especially when trying to get the diff level...I finally fell back to a piece of hose jammed on the gear oil bottle nozzle. Note that OEM was put on with silicone gasket goo (no gasket), so when you put a gasket in there you get some extra crush that will help seal your diff if the cover is a tiny bit off. ((And diff oil stinks...try not to get it on you)). Have fun!

Edit...reread your post...get the car safely on jack stands...basically put a large catch pan under the diff cover area and loosen the bolts enough to allow the cover to separate from the diff to let the old oil out. There is a 1/2" square head plug on the driver's side front---the oil goes back in there once the cover and new gasket are installed. Try to get the car/diff level and fill the diff until the oil is even with the bottom of the fill hole (it will seep out when you are there).
 
Last edited: May 5, 2020
Reactions: Misti

Misti

Member
Jun 23, 2019
31
9
18
Doniphan Mo
May 5, 2020
#3
  • May 5, 2020
  • #3
stormsedge said:
It looks like a jack was put in the wrong place and bent the cover lip up...alternatively, the car was driven over something high enough to bend the cover back, but it really looks like it was "lifted" from below. In any event, you might first try tightening the cover bolts a bit---don't overtorque them---to see if it stops the leak (if it does, top your diff oil off). If not, covers can be had fairly cheap from salvage, or from aftermarket suppliers. With that in mind, if tightening it doesn't stop the leak, there is no reason not to work it a little with a hammer to try and get a straight edge for a seal(use a straight edge to judge your work...ALSo, check to see if the cover is cracked. The hardest part of this job for me was figuring out a good way to get the oil back in it...a lot of obstructions on the front side, especially when trying to get the diff level...I finally fell back to a piece of hose jammed on the gear oil bottle nozzle. Note that OEM was put on with silicone gasket goo (no gasket), so when you put a gasket in there you get some extra crush that will help seal your diff if the cover is a tiny bit off. ((And diff oil stinks...try not to get it on you)). Have fun!

Edit...reread your post...get the car safely on jack stands...basically put a large catch pan under the diff cover area and loosen the bolts enough to allow the cover to separate from the diff to let the old oil out. There is a 1/2" square head plug on the driver's side front---the oil goes back in there once the cover and new gasket are installed. Try to get the car/diff level and fill the diff until the oil is even with the bottom of the fill hole (it will seep out when you are there).
Click to expand...
Ok, I am working on this at the moment! I'm kinda worried but Hopefully I can handle this one. I also read online about something in 4 oz. Called or said "Friction " to add with my gear oil! Is this true?
 

stormsedge

5 Year Member
Jun 17, 2018
450
208
63
Here
May 5, 2020
#4
  • May 5, 2020
  • #4
Misti said:
Ok, I am working on this at the moment! I'm kinda worried but Hopefully I can handle this one. I also read online about something in 4 oz. Called or said "Friction " to add with my gear oil! Is this true?
Click to expand...

You are referring to Ford Racing Additive Friction Modifier...comes in a 3.8 ounce plastic bottle...~$12. Used for posi rears and helps keep down chatter. I used it in mine, but the Royal Purple gear oil I used indicated it was not needed on their container, and indeed, some folks here do not use it. I guess it really depends on the grade of gear oil you have, what their claim is, and then make your best choice.
 
Reactions: Misti

Misti

Member
Jun 23, 2019
31
9
18
Doniphan Mo
May 5, 2020
#5
  • May 5, 2020
  • #5
stormsedge said:
You are referring to Ford Racing Additive Friction Modifier...comes in a 3.8 ounce plastic bottle...~$12. Used for posi rears and helps keep down chatter. I used it in mine, but the Royal Purple gear oil I used indicated it was not needed on their container, and indeed, some folks here do not use it. I guess it really depends on the grade of gear oil you have, what their claim is, and then make your best choice.
Click to expand...
Ok, That makes Good Sense! Thank You very Much! I appreciate your time in answering my questions!
 

Misti

Member
Jun 23, 2019
31
9
18
Doniphan Mo
May 5, 2020
#6
  • May 5, 2020
  • #6
stormsedge said:
You are referring to Ford Racing Additive Friction Modifier...comes in a 3.8 ounce plastic bottle...~$12. Used for posi rears and helps keep down chatter. I used it in mine, but the Royal Purple gear oil I used indicated it was not needed on their container, and indeed, some folks here do not use it. I guess it really depends on the grade of gear oil you have, what their claim is, and then make your best choice.
Click to expand...
Misti said:
Ok, That makes Good Sense! Thank You very Much! I appreciate your time in answering my questions!
Click to expand...
I do have one more question! What is this on there that looks like a cap? I added a picture!
 

Attachments

  • 15887139015871156053791850182236.webp
    102.7 KB · Views: 375

stormsedge

5 Year Member
Jun 17, 2018
450
208
63
Here
May 5, 2020
#7
  • May 5, 2020
  • #7
Misti said:
I do have one more question! What is this on there that looks like a cap? I added a picture!
Click to expand...

That is the rear axle vent bolt...it's purpose is to prevent pressure from building inside the rear diff/axle housing that would eventually cause leaks. Your leak is likely not this, as you have identified the gooned cover. Enjoy.
 
Reactions: Misti

Misti

Member
Jun 23, 2019
31
9
18
Doniphan Mo
May 14, 2020
#8
  • May 14, 2020
  • #8
stormsedge said:
That is the rear axle vent bolt...it's purpose is to prevent pressure from building inside the rear diff/axle housing that would eventually cause leaks. Your leak is likely not this, as you have identified the gooned cover. Enjoy.
Click to expand...
I fixed the leak! That was very easy! Everything went so Well. I Even took a few pictures of the inside of my differential! I straightened out the plate that was bent! Placed a New seal! I bought a pump to help put fluid back into it! That was a huge help! I appreciate all the help and info about this issue I was having with my car! I'm excited that its officially fixed! Thank You Very much!
 

Attachments

  • 20200508_163813.webp
    316.1 KB · Views: 511
Reactions: MattMan02GT, Poncho Villa, stormsedge and 1 other person

Noobz347

Stangnet Facilities Maint Tech... Er... Janitor
Admin Dude
Jan 4, 1985
43,115
21,288
234
Box behind Walmart
May 14, 2020
#9
  • May 14, 2020
  • #9
Congrats on making progress!


Is this a horrible time to mention that you need new suspension bushings?
 

Olivethefet

I will own your nuts! LOL
5 Year Member
May 17, 2018
2,596
1,790
143
Enterprise AL
May 14, 2020
#10
  • May 14, 2020
  • #10
In that last pic you have the car on a jack stand and I can see a jack on the other side. Did you have two jack stands under the car or were you using the jack to hold up one side of the car while you worked on it?
 

Noobz347

Stangnet Facilities Maint Tech... Er... Janitor
Admin Dude
Jan 4, 1985
43,115
21,288
234
Box behind Walmart
May 14, 2020
#11
  • May 14, 2020
  • #11
Olivethefet said:
In that last pic you have the car on a jack stand and I can see a jack on the other side. Did you have two jack stands under the car or were you using the jack to hold up one side of the car while you worked on it?
Click to expand...


If so, that is a nono

--and--


This guy calls it out in [every] image so...


Get more jack-stands. Yellow, bright orange, or fire engine red show up best in pictures.
 

Olivethefet

I will own your nuts! LOL
5 Year Member
May 17, 2018
2,596
1,790
143
Enterprise AL
May 14, 2020
#12
  • May 14, 2020
  • #12
Thats where I was going with the question. I just wanted to ask before making a big deal out of it.
 

stormsedge

5 Year Member
Jun 17, 2018
450
208
63
Here
May 14, 2020
#13
  • May 14, 2020
  • #13
Misti said:
I fixed the leak! That was very easy! Everything went so Well. I Even took a few pictures of the inside of my differential! I straightened out the plate that was bent! Placed a New seal! I bought a pump to help put fluid back into it! That was a huge help! I appreciate all the help and info about this issue I was having with my car! I'm excited that its officially fixed! Thank You Very much!
Click to expand...

Super! I'm happy it went well...a pump was smart!
 
You must log in or register to reply here.

Similar threads

B
97 GT with 03 explorer Eddie Bauer edition 4.6l
  • basbill73
  • May 10, 2026
  • 1996 - 2004 SN95 Mustang -General/Talk-
Replies
2
Views
68
1996 - 2004 SN95 Mustang -General/Talk- May 11, 2026
squeak93
L
2000 Mustang PATS - Broken Key and Wire - HELP!
  • Laree Taylor
  • May 7, 2026
  • 1996 - 2004 SN95 Mustang -General/Talk-
Replies
10
Views
212
1996 - 2004 SN95 Mustang -General/Talk- May 12, 2026
manicmechanic007
J
2004 Mustang 3.8L V6 vibrations above 65 MPH and differential leaks
  • joeybuddy96
  • Mar 16, 2026
  • SN95 V6 Mustang Tech
Replies
16
Views
592
SN95 V6 Mustang Tech Jul 14, 2026
joeybuddy96
J
2
Electrical mayhem
  • 2000ElectricGreen
  • Mar 13, 2026
  • 1996 - 2004 SN95 Mustang -General/Talk-
Replies
2
Views
282
1996 - 2004 SN95 Mustang -General/Talk- Mar 24, 2026
2000ElectricGreen
2
What's it Worth? 2000 GT
  • Mustang5L5
  • May 8, 2026
  • What is it Worth?!?!?
Replies
6
Views
312
What is it Worth?!?!? Jun 13, 2026
KRUISR
Share:
Bluesky Email Share Link
  • Mustang Forums
  • 1996 - 2004 SN95 Mustang -General/Talk-
Menu
Log in

Register

  • Forums
  • What's new
  • Media
  • Resources
  • Contact
  • Sponsor
X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?

X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?