• Mustang Forums
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
  • Fox 5.0 Mustang Tech

How to determine proper fuse and wire size?

  • Thread starter Thread starter 795.0
  • Start date Start date Mar 9, 2008
7

795.0

New Member
Dec 30, 2005
76
0
0
Mar 9, 2008
#1
  • Mar 9, 2008
  • #1
Does anyone have a link or chart that shows how many amps a given wire size can handle and how to determine proper fuse size?


I'm finally getting around to doing the 3g alternator swap with one rated at 160 amps. (tested at 177 amps max) from alterstart.com. Most articles/posts I've read deal with the 130 amp unit and use 4ga cable and fuses rated anywhere from 125 to 200 amps.
I saw one post that metioned 4ga cable was only good for 136 amps, yet alterstart sent a 4ga cable with this 177amp alt. I'll probably step up to 2ga cable for peace of mind.
Also, they specifically say in the directions, and told me over the phone, not to use any type of circuit breaker or fusible link between the alternator and battery. They also state doing so will void the warranty. I don't understand that and will probably run a fuse anyway, I just need to determine the proper size. Thanks.
 

jrichker

StangNet's favorite TOOL
In Remembrance. Thank you for your contributions
Mar 10, 2000
27,512
2,813
234
Dublin GA
Mar 9, 2008
#2
  • Mar 9, 2008
  • #2
Always use a fuse or fuseable link, or circuit breaker in any circuit. No exceptions.
Ford put a fuseable link because it was cheaper than a fuse (no fuse holder).

If the alternator develops an internal short to ground, and there is no circuit protection, you will have an electrical fire.
That electrical fire can burn up your car to a point that it is scap headed for the junkyard.

I would write anyone that sold me an alternator and told me not to use a fuse and ask if the are prepared
to pay the lawsuit and damages from a failure of their alternator.

 

Attachments

  • wire gauge, current capacity and lenght chart.GIF
    10.9 KB · Views: 28,587

HISSIN50

"How long does it take to get help in here?
15 Year Member
Nov 29, 1999
31,179
34
129
Mar 9, 2008
#3
  • Mar 9, 2008
  • #3
You won't find better advice than that above.


On the cable rating, my take: Some felt it was ok to reuse the stock charge wires in parallel with the new large gauge charge cable (we all know this is a bad idea). The rating of a 4 gauge cable and the additional load-bearing ability (on paper) of the stock wires allowed one to accomodate a larger than 130 amp alternator. Since we're not down with this practice, one needs to use one charge cable that's large enough to accomodate the entire alternator load by itself.

Good luck.
 
7

795.0

New Member
Dec 30, 2005
76
0
0
Mar 9, 2008
#4
  • Mar 9, 2008
  • #4
Thanks jrichker,
According to that chart I'll definitly go with 2ga wire.
Any idea on how to determine proper fuse size? I've heard it's a certain percentage of max amps, then I've heard it's slightly above max amps.
Thanks.
 

jrichker

StangNet's favorite TOOL
In Remembrance. Thank you for your contributions
Mar 10, 2000
27,512
2,813
234
Dublin GA
Mar 9, 2008
#5
  • Mar 9, 2008
  • #5
I would use a 160 amp fuse or somewhere in that range. Fuses will carry up to125% of their rating for an extended period of time without blowing.
 
You must log in or register to reply here.

Similar threads

For Sale 3-owner 1987 Mustang GT, $18K obro, Lancaster CA
  • Bill Cool
  • Oct 6, 2024
  • Fox Body Mustangs For Sale (1979-93)
Replies
4
Views
2K
Fox Body Mustangs For Sale (1979-93) Oct 13, 2024
nickyb
Electrical Starter blowing mega fuse to trunk battery
  • Waz900
  • Jun 27, 2022
  • Fox 5.0 Mustang Tech
Replies
18
Views
5K
Fox 5.0 Mustang Tech Oct 27, 2023
Rdub6
Fuel Fuel Pump Rewire, New Fuel Lines, and Installation of New Fuel Pump Hanger with AN6 Connections
  • AeroCoupe
  • Mar 12, 2023
  • Fox 5.0 Mustang Tech
  • 2
Replies
33
Views
13K
Fox 5.0 Mustang Tech Apr 16, 2023
AeroCoupe
SN Mustang Magnum T56 swap
  • revhead347
  • May 24, 2024
  • 1994 - 1995 Specific Tech
Replies
15
Views
6K
1994 - 1995 Specific Tech Jun 28, 2026
GearHeadGuy
J
98 GT ALT Fuse blowing
  • Jules98GT
  • Apr 6, 2021
  • SN95 4.6L Mustang Tech
Replies
1
Views
2K
SN95 4.6L Mustang Tech Apr 30, 2021
wmburns
Share:
Bluesky Email Share Link
  • Mustang Forums
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
  • Fox 5.0 Mustang Tech
Menu
Log in

Register

  • Forums
  • What's new
  • Media
  • Resources
  • Contact
  • Sponsor
X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?

X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?