My car has 10k on it.
1. AC Clicks so loud, you can hear it above the music (Ford can't fix it)
2. Front wheels click when you turn and move forward (Ford can't fix it, they are stumped)
3. Seat squeaks
4. Dash rattles by pass side on and off
5. My fuel pump had to be replaced
6. Something on the side of the pass seat rattles
7. Some times I can't put gas in the car
8. At 10k my car is out of alignment already
9. outside door handle stopped working
These problems seem to be par for the course. Then you have the water leak guys, vibration guys, axle whine guys etc.
Point is, buy an extended warranty or you'll be sorry!
Well all I can do is go by our warranty numbers. You have to remember I am looking a a lot bigger picture not just a single car or a handful of people.
Many of those problems you are reporting are not par for the course.
The problems we have seen so far are water leaks, batteries draining and clunking from the front end. Also we have had a few cars with rear end noise.
BTW your problems have some simple fixes.
1. the A/c concern, reduce the compressor clutch air gap with a smaller shim. This noise is caused by excessive a/c clutch air gap
2. the gas problem is most likely caused when they replaced your fuel pump they crimped some of the hoses, if they drop the tank they will find the pinched vapor hoses.
3. alignment can be messed up in 10 miles let alone 10k miles.. Something was hit to cause the alignment to go off. either that or the alignment is fine and road crowns are causing a pull. This is a normal condition.
The other stuff I would have had to be there to see what caused the concern, Fuel pump should not have went in 10k, but it happens. Who knows what happened to the handle and the rattles I would have to be there then I could tell you what happened
If your ford dealer is not able to handle this tell them I am willing to fly in. But I want 200 a hour while I am there plus expenses and a new mustang GT to drive while I am in town.
Why is it that the four fords I have bought brand new have been perfectly fine if they are such bad cars??
BTW I have worked for Honda, Audi and GM in the past and trust me all of those makes had issues too.