• Mustang Forums
  • 1996 - 2004 SN95 Mustang -General/Talk-

RPM Drops to idle intermittently when fuel tank is 1/4 full

  • Thread starter Thread starter Monkey
  • Start date Start date Jul 14, 2018
M

Monkey

New Member
Jul 14, 2018
1
0
1
Springfield, MA
Jul 14, 2018
#1
  • Jul 14, 2018
  • #1
Hello, Just put in a new gas tank into my 1997 SN95 mustang. Used all existing components except for new filler tube grommet. Filled the tank - no leaks = win, problem solved right?
Not. When the fuel gage got to just under 1/4 a tank, the RPM would drop to idle while driving on the highway. it would coast and then re-engage to full rpm and the drive train would engage... a few more miles, same thing, RPM would drop to idle speed and I had no acceleration... then re-engage to normal. Acted almost like it was out of gas, but the engine never completely shut off, just RPM lowered to idle setting.
Filled the tank and no problems, ran normal.... This only happened when the fuel level was just a smidge below 1/4 of a tank.
Could this be a tank baffle issue, a faulty fuel pump, or something else. I'm not looking forward to dropping the tank again as it was a pain getting it back in when I replaced it. The tank is new, but the components were reused (new fuel filter though & new filler neck grommet).
Thank You So Much as this has the Mrs. worried and scared to drive it now....
 

Neuron

5 Year Member
Nov 6, 2016
859
192
93
Jul 14, 2018
#2
  • Jul 14, 2018
  • #2
Why did you replace the tank? Since it started after this change it is most likely a result of that. I would check all of the lines and then I don't see anyway out of repulling the tank(I had to do mv '98 Cobra 3 times, got pretty used to it using a floor jack and piece of plywood)and checking out your work. Myself I would have replaced the pump while I was in there for peace of mind. You might also take pressure readings off the rail or using OBD2 software to verify.
 

wmburns

SN Certified Technician
Aug 14, 2009
5,892
514
204
Houston Texas
Jul 14, 2018
#3
  • Jul 14, 2018
  • #3
Exactly how much gas does it take to go from 1/4 tank to full?

Did you use a new fuel pump basket or service just the fuel pump?

Did you inspect the flexible line between the fuel pump and gas tank hat for leaks?

Did you inspect the fuel pump pick up sock to be sure it was clean and attached?

There are some small holes in the bottom ring of the fuel pump basket that are part of the baffle system. I could see a case where if these holes were plugged it could cause this symptom.

What I'm thinking is that the fuel pump is cavitating because it's not getting enough fuel covering the suction line. This is causing fuel to move but with too much air in the fuel. Any blockage or restriction of the suction line can cause cavitation
 
You must log in or register to reply here.

Similar threads

M
01 mustang 3.8 fuel pressure issue
  • Mhaley2006
  • May 29, 2026
  • 1996 - 2004 SN95 Mustang -General/Talk-
Replies
4
Views
225
1996 - 2004 SN95 Mustang -General/Talk- Sunday at 2:52 PM
JohnKay
J
I
1994 Cobra - Fuel Pressure Drops Revving at Idle
  • IconicSilverGT500
  • Apr 11, 2026
  • 1994 - 1995 Specific Tech
Replies
16
Views
481
1994 - 1995 Specific Tech Apr 24, 2026
Mcmahst
H
Fuel starvation issues, 91 EFI to carb swap. Car dying after 1-3 gallons used. EFI tank, electric fuel pump, bypass regulator. Dual fed carb
  • hassler
  • Oct 11, 2025
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
Replies
8
Views
793
1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk- Oct 12, 2025
nickyb
Hard to start when engine is cold
  • 86_Capri
  • Mar 11, 2026
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
  • 2
Replies
32
Views
1K
1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk- Jun 21, 2026
CAMTWO1070
B
'03 GT Fuel Pump/Pressure/Delivery Issue
  • Brodach
  • Oct 21, 2025
  • SN95 4.6L Mustang Tech
Replies
8
Views
929
SN95 4.6L Mustang Tech Oct 31, 2025
gkomo
Share:
Bluesky Email Share Link
  • Mustang Forums
  • 1996 - 2004 SN95 Mustang -General/Talk-
Menu
Log in

Register

  • Forums
  • What's new
  • Media
  • Resources
  • Contact
  • Sponsor
X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?

X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?