• Mustang Forums
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
  • 1994 - 1995 Specific Tech

Brake Booster Question - Is this a leak?

  • Thread starter Thread starter redsn95gt
  • Start date Start date Jun 16, 2011
R

redsn95gt

Member
Aug 5, 2010
143
0
16
Jun 16, 2011
#1
  • Jun 16, 2011
  • #1
When i had my engine bay stripped out for painting I decided to replace my rusting brake booster with a replacement piece from pep boys. Think I paid about $80 for it with core. Anyway, its a rebuilt model.

So as I am bleeding the brakes getting it ready to test drive, I'm discovering my pedal feel wasn't the best, soft mushy, going to the floor. Then I noticed when I depressed the brake pedal, I was hearing a air hiss. This hiss was coming from the vac hose attached to the brake pedal that has the valve that opens when you depress the pedal. So for giggles, I pulled the hose and valve off the pedal to mess with it. With the valve off, the hose is sucking air all the time, causing the hiss sound, and of course the valve opens it when its pushed in. Plugging the hose up while i push the pedal feels better, although its desperately trying to still suck air. My question is, is this normal operation? I don't recall if this was like this before I took the car apart so long ago. I also tested the cruise control switch on the brake pedal, didn't change anything, I removed the cruise control stuff from the car completely so the switch is probably useless now.

Is is possible to hook up the vac canister wrong and have a problem like this or is my brake booster faulty? I'm NOT looking forward to pulling out that booster again!
 

VibrantRedGT

"STANGNET'S PENGUIN SMACKER"
15 Year Member
Nov 29, 1999
14,679
424
154
Boca Raton, Florida
Jun 16, 2011
#2
  • Jun 16, 2011
  • #2
A faulty brake booster is the opposite of what you described. The pedal would be rock hard. Now if the vacuum line going to the booster was bad you will have weak brakes. A very mushy soft pedal is the master cylinder. When you bled the system there might be more air in the line, this causes a soft pedal too. If all the air is out and still having the soft pedal it will be a faulty master cylinder.
 

Adam95GT

New Member
Aug 14, 2006
2,564
3
0
Burlington, NJ
Jun 16, 2011
#3
  • Jun 16, 2011
  • #3
Did you bench bleed the master?
 
R

redsn95gt

Member
Aug 5, 2010
143
0
16
Jun 17, 2011
#4
  • Jun 17, 2011
  • #4
No, I did not bleed the master itself. I can do that tomorrow. Would this all contribute to the vac line at the pedal?
 

revhead347

Apparently my ex-husband made that mistake.
20+ Year Stangneter
Jun 14, 2004
9,297
1,641
214
Acworth, GA
Jun 17, 2011
#5
  • Jun 17, 2011
  • #5
The switch on the vac hose attached to the brake pedal is for the cruise control. What you described is normal operation. That switch has nothing to do with the brake booster. The valve for the brake booster is internal to the booster. The mushy feeling is probably just not what you are accustomed to, and indicates a very good brake booster. The vac canister in the fender is also for the cruise control, and has nothing to do with the brakes.

Kurt
 
R

redsn95gt

Member
Aug 5, 2010
143
0
16
Jun 22, 2011
#6
  • Jun 22, 2011
  • #6
Solved this problem just wanted to post my solution-

Bled the system using a harbor freight pressure/vacuum system that hooks to your air compressor. Its a knock of the more expensive units, this one worked fine for me, sometime harbor freight stuff is hit or miss.

Anyway, bled all 4 wheels in order RR,LR,RF,LF 2x. Did not bench bleed my master cylinder, read to try this first with the pressure system. I also used my little "one man" bleeder to confirm there was no air bubbles coming out the bleeder valves. 2 rounds and the thing was solid.

I did have a brake leak! I didn't notice fluid squirting all over the inside of my wheel. That was why my system wasn't pressurizing before. I had installed my rear passenger banjo bolt washers incorrectly. After fixing, leak went away and it was easy to fix.

Thanks all for the suggestions and help

Ryan
 

Chythar

Recently finished repairing my rear
20+ Year Stangneter
Aug 26, 2004
2,373
140
113
Foothill Ranch, CA
Jun 22, 2011
#7
  • Jun 22, 2011
  • #7
Obviously the fluid leak was causing your soft pedal that would sink to the floor. Good thing you caught that before you went for a test drive!
 
You must log in or register to reply here.

Similar threads

J
Emission problems
  • jls.zmmr
  • Feb 5, 2026
  • 1994 - 1995 Specific Tech
Replies
2
Views
243
1994 - 1995 Specific Tech Feb 7, 2026
AeroCoupe
1970 brake issue. Bad booster or?
  • All Stock93
  • May 13, 2025
  • 1965 - 1973 Classic Mustangs -General/Talk-
Replies
10
Views
711
1965 - 1973 Classic Mustangs -General/Talk- Sep 13, 2025
All Stock93
A
Resolved Brake light switch
  • Alabama
  • Feb 24, 2025
  • Fox 5.0 Mustang Tech
  • 2
Replies
31
Views
3K
Fox 5.0 Mustang Tech Jun 25, 2026
General karthief
8
87 lx 4cyl to v8 project 4 lug disc conversion questions
  • 87lx428
  • Mar 24, 2026
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
Replies
2
Views
501
1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk- Mar 25, 2026
87lx428
8
D
Brakes 1966 Mustang convertible 289, Auto - Disc brake conversion issues
  • DRGunn427
  • Feb 26, 2025
  • Classic Mustang Specific Tech
Replies
2
Views
629
Classic Mustang Specific Tech Jun 30, 2026
manicmechanic007
Share:
Bluesky Email Share Link
  • Mustang Forums
  • 1979 - 1995 (Fox, SN95.0, & 2.3L) -General/Talk-
  • 1994 - 1995 Specific Tech
Menu
Log in

Register

  • Forums
  • What's new
  • Media
  • Resources
  • Contact
  • Sponsor
X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?

X

Privacy & Transparency

We use cookies and similar technologies for the following purposes:

  • Personalized ads and content
  • Content measurement and audience insights

Do you accept cookies and these technologies?