Brakes Went To Bleed The Brakes Now I Have Leaking Fluid

Venom351R · May 27, 2012

Started to bleed the brakes and it is dripping fluid off a bolt from behind the caliper. No fluid came through the hose when the pedal was depressed. When the valve was closed and the brake released the fluid started to drip from this spot. Its coming right out from where this bolt goes in but I have no idea why, or what I need to do to fix it.

revhead347 · May 27, 2012

That sucks dude. I would make sure it isn't coming from anywhere else and dripping down there. Most likely it's leaking from the banjo joint on the brake cable. I don't think that screw goes through the casing. That spring is a bitch to re compres once it's off the caliper.

Kurt

Venom351R · May 28, 2012

It's deff coming from that bolt and not the banjo bolt. I can see it leaking from the base of the bolt when the access is wiped off

revhead347 · May 28, 2012

Well poop. I guess take the bolt out and see what happened.

Kurt

Venom351R · May 28, 2012

I'm going to put some pipe thread tape on the bolt and if it still leaks il just going to buy a new caliper. I'm not going to screw around with rebuilding the caliper when I can just bolt a new one on. I want to drive it I'm sick of working on it.

revhead347 · May 28, 2012

Don't lose any fingers putting that spring back on.

Kurt

Venom351R · May 28, 2012

Ya that worrys me to. I'll stop by ford on weds and see what I can get a caliper for. I think they are around $130

revhead347 · May 28, 2012

You'd go to the dealer for a caliper. Mucho cheaper at the Autoparts store. Pretty much guaranteed they are both rebuilt by the same company in Mexico.

Kurt

Venom351R · May 29, 2012

I'll check both.

Venom351R · May 30, 2012

NAPA has them for $50. I'll go home today and take mine off and bring it in so I can get the core charge refund right then.

revhead347 · May 30, 2012

You might want to hold off on an instant core refund. There might be parts off the orignal caliper you need to swap to the new one.

Kurt

1slow95 · May 30, 2012

One of my rear calipers locked up and I replaced it with one from auto zone. I don't remember using anything from the old caliper. You still might want to leave the old one installed to minimize brake fluid loss. My cousin left his front brakes off overnight and ended up with air in the master cylinder. That's an easy fix if you have bleeders on the MC, but I don't believe these cars have them.

revhead347 · May 30, 2012

I just turn the cable up and zip tie it. You don't get a whole lot of brake fluid loss. If you don't have synthetic fluid in there, and it's been more than a few years, it's time to flush it all out anyway. Usually crap like that goes bad because water builds up in DOT 3 brake fluid.

Kurt

Venom351R · May 30, 2012

The caliper I got has everything except pads, it will be here in the morning.

revhead347 · May 30, 2012

That's an excellent deal then. I'll know where to go nedt time I need a caliper.

Kurt

Venom351R · May 30, 2012

came to $58 with tax and will be there when they open at 7:30. I did not have much brake fluid in the system anyway. When I took the banjo bolt out nothing else dripped out, I think it leaked out everything I dumped into it. Now just crossing my fingers that when I get it on and go to bleed the system again that the left one is not toast as well.

http://www.napaonline.com/Catalog/CatalogItemDetail.aspx?R=SEBSE5095B_0248591243

Brakes Went To Bleed The Brakes Now I Have Leaking Fluid

Venom351R

revhead347

Apparently my ex-husband made that mistake.

Venom351R

revhead347

Apparently my ex-husband made that mistake.

Venom351R

revhead347

Apparently my ex-husband made that mistake.

Venom351R

revhead347

Apparently my ex-husband made that mistake.

Venom351R

Venom351R

revhead347

Apparently my ex-husband made that mistake.

1slow95

revhead347

Apparently my ex-husband made that mistake.

Venom351R

revhead347

Apparently my ex-husband made that mistake.

Venom351R

Similar threads

Brakes Went To Bleed The Brakes Now I Have Leaking Fluid

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Apparently my ex-husband made that mistake.

Similar threads

Privacy & Transparency

Privacy & Transparency